QBO變壓吸附氧氣設備，QBO-80

       壓縮空氣經空氣凈化系統除去油、水、塵埃等雜質后進入裝有沸石分子篩的吸附塔，空氣中的氮氣、二氧化碳、水蒸汽等被分子篩大量吸附，而氧氣由于擴散速率大而穿過吸附劑，而實現氧、氮分離。 
       當吸附塔內吸附的氮等雜質達到飽和后，降低壓力使沸石分子篩解吸再生，得以重復循環使用。 
       采用兩個吸附塔在PLC的控制下循環工作，連續產出高品質的氧氣。 
QBO PSA Oxygen Generator
The Working Principle
       Compressed air through the air purification system to remove oil , water , dust and other impurities . Then enter into the zeolite molecular sieve adsorption tower . Most nitrogen , ,carbon dioxide and water vapor in the air adsorbed by molecular sieve . Because of the high spread rate of passing the adsorbent , the oxygen gas and nitrogen gas finally be separated.
The two adsorption tower circulation work under the control of PLC and output high quality oxygen continuously.
技術特點：

1. 設備運行能耗低，成本少，適應性強，產氣快速，純度易調節；
2. 完善的工藝流程設計，最有使用效果；
3. 模塊化結構設計，節省占地面積；
4. 操作簡單，性能穩定，自動化程序高，可實現無人運行；
5. 合理的內部構件，氣流分布均勻，減輕氣流高速沖擊；
6. 特有的沸石分子篩保護措施，延長沸石分子篩的使用壽命；
7. 關鍵部件采用著名品牌是設備品質的有效保證；
8. 國際專利技術的自動防控裝置，保證成品氧氣品質；
9. 具有多種故障診斷、報警及自動處理功能；
10. 可選配觸摸式屏幕顯示、露點檢測、節能控制、DCS通信等；

Technical characteristics

1. Unique molecular sieve protective measures so as to lengthen the service life of zeolite molecular sieve.
2. Self-reliance type cylinder pressure device can avoid high-speed airflow rushed out ,it can not cause of molecular sieve pulverization phenomenon .equipped with the limit settlement alarm system , when it can not reach the level of purity , the equipment will sound and light alarm by itself.
3. Configured DCS remote control system interface ,it can monitor the system operate condition through the computer.
4. Intelligent interlocking nitrogen vent device can guarantee the quality of nitrogen.
5. Perfect process design and excellent energy conservation characteristics reduce the cost of gas .
6. Reasonable structure design make the transportation ,sling and installation very convenient.
7. Selecting the safe and reliable control components, so the equipment can run stable and reliable , it also has various fault alarm .
8. It operates easily , runs stably , and has a high degree of automation , can realize no one operates.

技術指標(Technical parameters)

1. 氧氣產量(Capacity)：1～200 Nm³/h
2. 氧氣純度(Purity)：90％～93％
3. 氧氣壓力(Pressure)：0.1～0.7 Mpa（可調 can be adjusted）
4. 氧氣露點(Dew point)：－40℃或－60℃

注：由于產品配套不同，具體價格請咨詢